All Issue

2025 Vol.43, Issue 2 Preview Page

Research Article

Analysis of Heavy Metals, Residual Pesticides, Inorganic Substances, and Leachate in Rock Wool and Coir Substrates used for Paprika Cultivation
Yoon Go1†
,
Se Hun Ju2†
,
Eun Ji Kim2
,
Jun Gu Lee3
,
Jongseok Park4
,
Daegi Kim5
,
Haeyoung Na6*
1Department of Horticultural Science, Graduate School of Mokpo National University, Muan 58554, Korea
2Interdisciplinary Program of Development and Utilization of Biological Resources, Graduate School of Mokpo National University, Muan 58554, Korea
3Department of Horticulture, University of Agriculture & Life Sciences, Jeonbuk National University, Jeonju 54896, Korea
4Department of Horticultural Science, Chungnam National University, Daejeon 34134, Korea
5Department of Environmental Engineering, Mokpo National University, Muan 58554, Korea
6Department of Horticulture and Forestry, College of Life and Medical Sciences, Mokpo National University, Muan 58554, Korea
*Corresponding Author
†These authors contributed equally to this work.
30 April 2025. pp. 234-244
PDF XML Citation
Abstract

This study evaluated the recyclability of rock wool and coir substrates used for paprika cultivation by analyzing their compositions and potential hazards. The heavy metal contents were determined before and after cultivation, and residual pesticides and inorganic substances were measured after cultivation. The leachate generated from soaking the coir substrates was analyzed for its heavy metal, chloride ion, and salinity contents. The concentrations of copper (Cu), nickel (Ni), lead (Pb), and zinc (Zn) contained in the rock wool substrates before and after use were below the threshold values set by the Soil Environment Conservation Act for soil contamination concerns in region 1 (paddy fields, dry fields, orchards, pastures, and mineral spring sites) in South Korea. The rock wool substrate exceeded the threshold values set by the Soil Environment Conservation Act for soil contamination concerns in region 1. However, hexavalent chromium (Cr6+) was not detected, and only trivalent chromium (Cr3+), which has less of an impact on human health and the environment, was found. In contrast, the heavy metal content in the coir substrate was below the threshold set for soil contamination in region 1, confirming that it poses no environmental concerns. A residual pesticide analysis revealed that only dinotefuran was detected in rock wool. In the coir substrate, three insecticides (chlorantraniliprole, chlorfenapyr, dinotefuran) and three fungicides (boscalid, procymidone, fluxapyroxad) were detected. However, all were below the maximum residue limits set by the Ministry of Food and Drug Safety. Rock wool and coir substrates contain the inorganic components N, B, Ca, K, Mg, Mn, Na, P, and Si. The rock wool substrate was particularly high in silicon and calcium, whereas the coir substrate had a high nitrogen content. These results suggest that rock wool and coir substrates can be recycled as soil conditioners or fertilizers. Additionally, it was confirmed that the leachate generated during pre-cultivation soaking of the coir substrate could be discharged without causing environmental issues.

Keywords
fungicides
insecticides
pre-cultivation socking process
recycling
soil contamination
water pollutants
References
1

Abou-Elela SI, Kamel MM, Fawzy ME (2010) Biological treatment of saline wastewater using a salt-tolerant microorganism. Desalination 250:1-5. https://doi.org/10.1016/j.desal.2009.03.022

10.1016/j.desal.2009.03.022
2

Acuna T, Bonachela S, Magan J, Marfa O, Hernandez J, Caceres R (2013) Reuse of rockwool slabs and perlite grow-bags in a low-cost greenhouse: substrates' physical properties and crop production. Sci Hortic 160:139-147. https://doi.org/10.1016/j.scienta.2013.05.031

10.1016/j.scienta.2013.05.031
3

Al-aghabary K, Zhu Z, Qinhua S (2004) Influence of silicon supply on chlorophyll content, chlorophyll fluorescence, and antioxidative enzyme activities in tomato plants under salt stress. J Plant Nutr 27:2101-2115. https://doi.org/10.1081/PLN-200034641

10.1081/PLN-200034641
4

Allaire SE, Caron J, Ménard C, Dorais M (2005) Potential replacements for rockwool as growing substrate for greenhouse tomato. Can J Soil Sci 85:67-74. https://doi.org/10.4141/S04-026

10.4141/S04-026
5

Arora J, Ramawat KG, Merillon JM (2023) Disposal of agricultural waste and its effects on the environment, production of useful metabolites and energy: potential and challenges. Sustainable Dev Biodivers https://doi.org/10.1007/978-981-19-8774-8_1

10.1007/978-981-19-8774-8_1
6

Below FE (2002) Nitrogen matabolism and crop productivity. Handbook of plant crop physiology. Marcel Dekker, New York, pp 275-301. https://doi.org/10.1201/9780203908426.ch18

10.1201/9780203908426.ch18
7

Burnett WE (1974) The effect of salinity variations on the activated sludge process. Water Sew Works 121:37-38

8

Bussell WT, Mckennie S (2004) Rockwool in horticulture, and its importance and sustainable use in New Zealand. N Z J Crop Hortic Sci 32:29-37. https://doi.org/10.1080/01140671.2004.9514277

10.1080/01140671.2004.9514277
9

Choi SH, Lim MY, Choi GL, Kim SH, Jeong HJ (2019) Growth and quality of two melon cultivars in hydroponics affected by mixing ratio of coir substrate and different irrigation amount on spring season. Protected Hortic Plant Fac 28:376-387. https://doi.org/10.12791/KSBEC.2019.28.4.376

10.12791/KSBEC.2019.28.4.376
10

Datnoff LE, Deren CW, Snyder GH (1997) Silicon fertilization for disease management of rice in Florida. Crop Prot 16:525-531. https://doi.org/10.1016/S0261-2194(97)00033-1

10.1016/S0261-2194(97)00033-1
11

Epstein E (1994) The anomaly of silicon in plant biology. Proc. Natl. Acad. Sci. USA, 91:11-17. https://doi.org/10.1073/pnas.91.1.11

10.1073/pnas.91.1.1111607449PMC42876
12

Food and Agriculture Organization (FAO) (2011) Evaluation of pesticide residues for estimation of maximum residue levels and calculation of dietary intake: training manual. https://www.fao.org

13

Gale ES, Sullivan DM, Cogger CG, Bary AI, Hemphill DD, Myhre EA (2006) Estimating plant-available nitrogen release from manures, composts, and specialty products. J Environ Quality 35:2321-2332. https://doi.org/10.2134/jeq2006.0062

10.2134/jeq2006.006217071903
14

Gilewska M (2006) Utilization of wastes in reclamation of post mining soils and ash dump sites. Roczniki Gleboznawcze 57:75-81

15

Grodan (2022) Recycling solution. https://www.grodan.com/

16

Hongpakdee P, Ruamrungsri S (2015) Water use efficiency, nutrient leaching, and growth in potted marigolds affected by coconut coir dust amended in substrate media. Hortic Environ Biotechnol 56:27-35. https://doi.org/10.1007/s13580-015-0064-7

10.1007/s13580-015-0064-7
17

Hossein HA, Hamzawy EMA, El-bassyouni GT, Nabawy BS (2023) Mechanical and physical properties of synthetic sustainable geopolymer binders manufactured using rockwool, granulated slag, and silica fume. Constr Build Mater 367:130-143. https://doi.org/10.1016/j.conbuildmat.2022.130143

10.1016/j.conbuildmat.2022.130143
18

International Agency for Research on Cancer (IARC) (2002) Man-made vitreous fibres, 81. https://www.iarc.fr

19

Jaroszuk-Sierocińska M, Słowińska-Jurkiewicz A, Bryk M, Kołodziej B (2014) Estimation of structure and water and air properties of grodan rockwool waste after production cycle. Pol J Environ Stud 23:2039-2045

20

Kim GH, Jeong BR (2003) Hydroponic culture of a pot plant Ficus benjamina 'King' using mixtures of used rockwool slab particles and chestnut woodchips. J Korean Soc For Hortic Sci 44:251-254

21

Kim M, Lee JJ, Kim DY, Park SU, Kwon SC (2004) The trend of study of echo-friendly hard trivalent chromium deposition. J Korean Inst Surf Eng 37:179-184

22

Kincannon DF, Gaudy AF (1966) Some effect of high salt concentration on activated sludge. J Water Poll Cont Fed 38:1148-1159

23

Kincannon DF, Gaudy AF (1968) Response of biological waste treatment system to changes in salt concentrations. Biotechnol Bioeng 10:483-496. https://doi.org/10.1002/bit.260100408

10.1002/bit.260100408
24

Lee SG, Choi EY, Lim GH, Choi KY (2017) Yield and inorganic ion contents in drained solution by different substrate for hydroponically grown strawberry. Hortic Sci Technol 36:337-349. https://doi.org/10.12972/kjhst.20180033

10.12972/kjhst.20180033
25

Lee SK, Sohn EY, Hamayun M, Yoon JY, Lee IJ (2010) Effect of silicon on growth and salinity stress of soybean plant grown under hydroponic system. Agrofor Syst 80:333-340. https://doi.org/10.1007/s10457-010-9299-6

10.1007/s10457-010-9299-6
26

Lim MY, Choi SH, Choi GL, Kim SH, Jeong HJ (2020a) Effects of irrigation amount on fruiting period and EC level by growth period on growth and quality of melon (Cucumis melo L.) using coir substrate hydroponics during autumn cultivation. Hortic Sci Technol 39:446-455. https://doi.org/10.7235/HORT.20210040

10.7235/HORT.20210040
27

Lim MY, Choi SH, Jeong HJ, Choi GL (2019) Characteristics of comestic net type melon in hydroponic spring cultivars using coir substrates. Hortic Sci Technol 38:78-86. https://doi.org/10.7235/HORT.20200008

10.7235/HORT.20200008
28

Lim MY, Choi SH, Jeong HJ, Choi GL (2020b) coir substrates. Korean J Hortic Sci Technol 38:78-86. https://doi.org/10.7235/HORT.20200008

10.7235/HORT.20200008
29

Ma JF, Takahashi E (2002) Soil, fertilizer, and plant silicon research in Japan. Elsevier Publishing Company. https://doi.org/10.116/B978-044451166-9/50009-9

30

Mathur AK, Chandra SV, Tandon SK (1977) Comparative toxicity of trivalent and hexavalent chromium to rabbits II. Morphological changes in some organs. Toxicology 8:53-61. https://doi.org/10.1016/0300-483X(77)90023-3

10.1016/0300-483X(77)90023-3929618
31

Ministry of Agriculture, Food and Rural Affairs (MAFRA) (2018) Present status of greenhouse and vegetable production in 2017. Sejong, Korea, pp 52-165.

32

Ministry of Environment (ME) (2017) Soil environment conservation act. https://www.me.go.kr/

33

Ministry of Environment (ME) (2021) Designation of water pollutants and setting of discharge permit standards (Draft) -Chlorinated Compounds, Sulfur and Its Compounds, Hexachlorobenzene. https://www.me.go.kr/

34

Ministry of Environment (ME) (2023) Water environment conservation act. https://www.me.go.kr/

35

Ministry of Food and Drug Safety (MFDS) (2022) Multi-residue analysis method. https://www.mfds.go.kr/

36

Muyzer G (1999) DGGE/TGGE a method for identifying genes from natural ecosystems. Curr Opin Microbiol 2:317-322. https://doi.org/10.1016/S1369-5274(99)80055-1

10.1016/S1369-5274(99)80055-110383868
37

Obi FO, Ugwuishiwu BO, Nwakaire JN (2016) Agricultural waste concept, generation, utilization and management. Nigerian J Technol 35:957-964. https://doi.org/10.4314/njt.v35i4.34

10.4314/njt.v35i4.34
38

Park KW, Lee HS, Kang HM (2003) Effect of recycled substrates culture on the growth and some quality components of hydroponically grown cucumber. J Bio-Env Con 12:160-165

39

Raviv MR, Wallach A, Silber, Bar-Tal A (2002) Substrates and their analysis. In D. Savvas. H Passam, eds, Hydroponic production of vegetables and ornamentals. Ebryo Pub, pp 25-102.

40

Rhie YH, Kang SH, Choi JM, Kim JY (2017) Physical and chemical properties of bottom ash and coir dust mix used as horticulturalldldl substrates. Hortic Sci Technol 36:161-171. https://doi.org/10.12972/kjhst.20180017

10.12972/kjhst.20180017
41

Rincón L, Pérez A, Abadia C, Pellicer C (2005) Yield, water use and nutrient uptake of a tomato crop grown on coconut coir dust. Acta Hortic 697:73-79. https://doi.org/10.17660/ActaHortic.2005.697.7

10.17660/ActaHortic.2005.697.7
42

Rural Development Administration (RDA) (2013) Nutrient solution management technology of strawberry in high bed hydroponic cultivation. Suwon, Korea. https://www.rda.go.kr/

43

Rural Development Administration (RDA) (2021) Agricultural Technology Guide Hydroponics. https://www.rda.go.kr/

44

Suzuki Y, Nomma K, Minami M, Yoshikawa H (1984) Distribution of chromium in rats exposed to hexavalent chromium and trivalent chromium aerosols. Industrial Health 22:261-277. https://doi.org/10.2486/indhealth.22.261

10.2486/indhealth.22.2616526701
45

Taiz L, Zeiger E (2009) Plant physiology. Life Science Seoul, Korea, pp 295-302

46

White PJ, Broadley MR (2003) Calcium in plants. Annals of Botany 92:487-511. https://doi.org/10.1093/aob/mcg164

10.1093/aob/mcg16412933363PMC4243668
47

Woolard CR, Irvine RL (1995) Treatment of hypersaline wastewater in the sequencing batch reactor. Water Res 29:1159-1168. https://doi.org/10.1016/0043-1354(94)00239-4

10.1016/0043-1354(94)00239-4
48

Xi J, Qiu Y, Du L, Poovaiah BW (2012) Plant-specific trihelix transcription factor AtGT2L interacts with calcium/calmodulin and responds to cold and salt stresses. Plant Sci 185-186:274-280. https://doi.org/10.1016/j.plantsci.2011.11.013

10.1016/j.plantsci.2011.11.01322325890
49

Yap ZS, Khalid NHA, Haron Z, Mohamed A, Tahir MM, Hasyim S, Saggaff A (2021) Waste mineral wool and its opportunities-a review. Materials https://doi.org/10.3390/ma14195777

10.3390/ma1419577734640174PMC8510145
50

Yörükoğlu A, Akkurt F, Çulha S (2020) Investigation of boron usability in rock wool production. Constr Build Mater 243:118-222. https://doi.org/10.1016/j.conbuildmat.2020.118222

10.1016/j.conbuildmat.2020.118222
Information
  • Publisher :KOREAN SOCIETY FOR HORTICULTURAL SCIENCE
  • Publisher(Ko) :한국원예학회
  • Journal Title :Horticultural Science and Technology
  • Journal Title(Ko) :원예과학기술지
  • Volume : 43
  • No :2
  • Pages :234-244
  • Received Date : 2024-10-07
  • Revised Date : 2024-10-31
  • Accepted Date : 2024-11-11
  • DOI :https://doi.org/10.7235/HORT.20250026
Journal Informaiton Horticultural Science and Technology Horticultural Science and Technology
Online Submission
  • scopus
  • NRF
  • KOFST
  • crossref crossmark
  • crossref cited-by
  • crosscheck
  • orcid
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close